Note: Each Ac Air Compressor Comes with 100ml of Oil. You Dont Need to Add Oil Additionally.
Fit For: For Hyundai Sonata 2011 For KIA Optima 2011 2.0 & 2.4
Number: 10349930, 1011218, 7512961, 256161, CO 11218C 639966, 178317, 178328, 7512958, 977013R000, C2629, 4716044, 977013R000RU, 2021813, 0610307
The System (Compressor Installation)
5 Year Warranty & Agreement
Follow All Local,State and Federal Regulations When Servicing Mobile a/C Systems and Read This Instruction Sheet Prior to Starting Any Repairs.
Oil Charges and Oil Types Should Be Closely Adhered to for Proper a/C Performance.
If You Are Uncertain of Oil Charge or Refrigerant Total System Charge Refer to the Under Hood Decal or, Oem Service Manual.
Use Only R-12 or R-134a Refrigerant.
1. Remove Compressor, Receiver Drier or Accumulator, Orifice Tube or Expansion Valve.
2. Flush the Condenser and Evaporator Using Non-oil Based a/C Flush. on Expansion Valve Systems the Valve Must Be Removed Before the Evaporator Can Be Flushed. Flushed Condensers from Outlet to Inlet and Evaporators from Inlet to Outlet.
Warning: Newer Style Condenser Designs Are Very Hard, and Sometime It Would Be Impossible to Do Flush, in Those Cases It Is Suggested That If the Compressor Has a Major Failure the Condenser Should Be Replaced.
3. Drain All the Oil from the New Compressor and Dispose of According to Local, State and Federal Laws. Note: If You Compressor Has a Drain Plug You Will Need to Open It up and Drain What Oil Is in There Too,
4. Install Half Oil Charge into the Compressor and the Remainder Throughout the System. Turn Compressor Shaft 8-10 Full Revolutions to Insure Front Seal and Other Internal Parts Are Lubricated.
5. Install New Receiver Drier or Accumulator and New Orifice Tube or Expansion Valve.
6. Evacuate the a/C System for a Minimum of One Hour.
7. After Evacuation Install Half the Refrigerant Charge and Let the System Set for 1 Minute. This Will Allow the Refrigerant to Pick up Oil and Spread More Evenly Throughout the System.
8. Start Engine Whit a/C Controls on Max Air with Door and Windows Open.
9. Add the Remaining Charge of Refrigerant As Called for by the Manufacture.
Installation Method
Attention Please:
Be Sure to Clean the Air Conditioning System Before Installation, Otherwise It Will Cause Compression Broken.
1. Remove Compressor:
Remove the a/C Belt from the a/C Compressor Pulley. May Involve Loosening the Belt Tensioner (If Equipped).
2.Receiver Drier or Accumulator, Orifice Tube or Expansion Valve.
3.Disconnect the Negative Battery Cable.
4.Remove the Bolt That Secures Refrigerant Lines to the a/C Compressor. Inspect a/C Lines for Any Contamination Such As Metal or Excessive Dirt Inside of Them. If You Find Any Contamination the System Will Need to Be Cleaned.flush the Condenser and Evaporator Using Non-oil Based a/C Flush. on Expansion Valve Systems. the Valve Must Be Removed Before the Evaporator Can Be Flushed. Flushed Condensers from Outlet to Inlet and Evaporators from Inlet to Outlet.
5.Drain All the Oil from the New Compressor ,If You Compressor Has a Drain Plug You Will Need to Open It up and Drain What Oil Is in There Too.
6.Install Half Oil Charge into the Compressor and the Remainder Throughout the System. Turn Compressor Shaft 8-10 Full Revolutions to Insure Front Seal and Other Internal Parts Are Lubricated.
7.Install New Receiver Drier or Accumulator and New Orifice Tube or Expansion Valve.
8.Evacuate the a/C System for a Minimum of One Hour.
9.After Evacuation Install Half the Refrigerant Charge and Let the System Set for 1 Minute. This Will Allow the Refrigerant to Pick up Oil and Spread More Evenly Throughout the System.
10.Turn on the a/C System with the Engine Running and Check to See If Cold Air Is Now Coming out of the Air Duct.
11.If the a/C System Is Functioning ,You May Find That Your Electric Radiator Fan and Compressor Clutch Will Be Cycling off and on Depending on the Outside Air Temperature
Take Appropriate Safety Precautions:
1. Wear Eye Protection (Safety Glasses).
2. Do Not Smoke Next to the Vehicle When Performing Repairs.
3. Work in a Well-ventilated Area.
4. Wear Skin Protection (Such As Gloves and Closed Toe Shoes).
Pay Attention
This Compressor Comes Pre-filled with the Correct Amount of Oil. There Is No Need to Add Any Additional Oil to Your System.
Please Add 70-80% Refrigerant, Do Not Need to Fill up
Noise Is Generated If Too Much Refrigerant Is Added
Package Included:
1pc A/C Compressor（Professional Installer Is Highly Recommended ）
Three stars is LOW star, NO 1,2,3 stars PLEASE!
Please give us Five-star!
I have a question about using my item or I want to send the seller a message(0)(YES)
I did not receive my item(2)(NO)
I need to return my item(1)(NO)
I receive an item that was not as described(1)(NO)
Request to cancel this order(1)(NO)
